The Hydrolytic Polymerization Model of the Gangue-Basic PAFC by Microwave Irradiation

连明磊; 胡江良; 孔德顺; 冯权莉; 艾德春

您当前的位置：

首页 >

文章列表页 >

The Hydrolytic Polymerization Model of the Gangue-Basic PAFC by Microwave Irradiation

更新时间：2026-09-14

- The Hydrolytic Polymerization Model of the Gangue-Basic PAFC by Microwave Irradiation
- 煤矸石基聚合氯化铝铁微波水解聚合过程模型
- Vol. 33, Issue 6, Pages: 716-720(2012)
- 作者机构：
  
  1. 六盘水师范学院环境与化学工程系
  2. 昆明理工大学化学工程学院
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Published：2012
- 稿件说明：
移动端阅览
连明磊, 胡江良, 孔德顺, et al. The Hydrolytic Polymerization Model of the Gangue-Basic PAFC by Microwave Irradiation[J]. 2012, 33(6): 716-720.
DOI：

连明磊, 胡江良, 孔德顺, et al. The Hydrolytic Polymerization Model of the Gangue-Basic PAFC by Microwave Irradiation[J]. 2012, 33(6): 716-720. DOI：

摘要

设计了煤矸石微波法制聚合氯化铝铁的工艺流程.考虑了微波效率及体系向环境的热传导

通过相关试验

计算得到了煤矸石基聚合氯化铝铁在微波场中的水解聚合能E=257.05kJ·mol-1.引入了Ea=E的假设

建立了煤矸石基聚合氯化铝铁微波水解聚合的反应动力学方程.研究表明:320W微波功率下

反应动力学拟合方程的反应级数β=0.140

表观频率因子k0=1.10×10\+-3mol0.860·L-0.860·s-1

模型计算值与试验值拟合良好

相关系数R=0.999 9.在528W及680W两功率水平下过程模型的计算值也均与试验值拟合良好

Abstract

The flow charts for hydrolytic polymerization of the gangue-basic PAFC by microwave irradiation were designed.The microwave efficiency and heat conduction were considered

and the hydrolytic polymerization energy of the gangue-basic PAFC by microwave irradiation is identified as E=257.05 kJ·mol-1 through the related tests.Assuming Ea is equal to E

the kinetics was established.The reaction order is identified as β=0.140

and the apparent frequency factor is identified as k0=1.10×10-3 mol0.860·L-0.860·s-1 when the microwave power is 320 W.Also

the kinetic model fits well with the experimental values

and the correlation coefficient is 0.999 9.The similar situations occur in other powers

and the correlation coefficients are higher than 0.999 8 when the microwave power is 528 W or 680 W.

关键词

Keywords

references

郑怀礼,杨铀,唐雪,等.微波促进类Fenton反应催化氧化脱色降解染料罗丹明B[J].光谱学与光谱分析,2009,29(8):2180-2184.Zheng Huaili,Yang You,Tang Xue,et al.Decoloration and degradation of rhodamine B bymicrowave-promoted Fenton-like reaction[J].Spectroscopy and Spectral Analysis,2009,29(8):2180-2184.(in Chinese)

万立国,田禹,张丽君,等.活性炭辅助微波热解污泥反应条件的试验研究[J].生态环境学报,2010,19(9):2182-2186.Wan Liguo,Tian Yu,Zhang Lijun,et al.Experimental study on reacting conditions ofmicrowave pyrolyzing sewage sludge induced by activecarbon[J].Ecology and Environmental Sciences,2010,19(9):2182-2186.(in Chinese)

Gabriel C,Gabriel S,Brant EH,et al.Dielectricparameters relevant to microwave dielectric heating[J].Chemical Society Review,1998,27:217-223.

Metaxas A C,Meredith R J.Industrial microwaveheating[J].Power Engineering Series 4.PeterPeregrinus Ltd.(On behalf of IEE),1993,23(5):5-18.

Hill J M,Marchant T R.Modeling microwave heating[J].Applied Mathematical Modeling,1996,20(1):3-15.

Reimbert C G,Minzoni A A,Smyth N F.Effect ofradiation losses on hotspot formation and propagationin microwave heating[J].IMA Journal of AppliedMathematics,1996,57(2):165-179.

夏祖学,刘长军,闫丽,等.微波化学的应用研究进展[J].化学研究与应用,2004,16(4):441-444.Xia Zuxue,Liu Changjun,Yan Li,et al.Progress inmicrowave chemistry research and applications[J].Chemical Research and Application,2004,16(4):441-444.(in Chinese)

Thostenson E T,Chou T W.Microwave processing:fundamentals and applications[J].Composites:PartA:Applied Science and Manu-Facturing,1999,30(9):1055-1071.

孙利强,韩秀峰.使用煤矸石生产聚合双酸铝絮凝剂的技术探讨[J].内蒙古电力技术,2010,28(4):42.Sun Liqiang,Han Xiufeng.Technical discussion topoly aluminum chloride flocculation agents producedby coal gangue[J].Inner Mongolia Electric Power,2010,28(4):42.(in Chinese)

Vence T D,Powers D L.Resource recovery systems[J].Technol Comparison Solid Wastes Manage/Resource Recovery,1980(5):6-11.

Gao B Y,Yue Q Y,Wang B J.The Chemical speciesdistribution and transformation of polyaluminumsilicate chloride coagulant[J].Chemosphere,2002,46:809-813.

马艳然,于伯蕖,鲁秀国.从煤矸石中制备聚合氯化铝及应用研究[J].化学世界,2004(2):63-65.Ma Yanran,Yu Boqu,Lu Xiuguo.Study on thepreparation of polyaluminum chloride from coalgangue[J].Chemical World,2004(2):63-65.(in Chinese)

Carr M J,Lewis D H,Burr R V,et al.ANSI/ASTM D2766-1995 Test Method for SpecificHeat of Liquids and Solids[S].1995.

全国化学标准化技术委员会.GB15892-2003水处理剂聚氯化铝[S].北京:中国标准出版社,2003.

陈敏恒,丛德滋,方图南,等.化工原理(上册)[M].北京:化学工业出版社,1999:387-388.

Views

147

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Application Study on Dissociation of Coal Gangue by Myroides Odoratimimus Strain and Bacillus Megaterium

Dynamic Study of Removal of SeO42- in Water with Stabilized ZVI Nanoparticles

Network Intrusion Detection Model Based on Recurrence Plot and MobileViT⁃AESTF

High⁃Precision Photoeletric Coordinate Positioning Technology Based on Transformer⁃FPGA Collaborative Feature Modeling

Research Progress on Single⁃Photon Detection for Quantum Information About Mechanisms，Devices and Circuit Design

Related Author

李夏夏

钟艳

谢承卫

刘宏芳

钱天伟

张敏刚

赵东叶

Related Institution

贵州大学化学与化工学院

太原科技大学环境与安全学院

奥本大学土木工程系

⁰