聚铁与聚铝联用处理草浆造纸中段废水的研究

杨宇; 刘锐; 朱勇强; 刘德永; 易玉林; 丁国际

您当前的位置：

首页 >

文章列表页 >

聚铁与聚铝联用处理草浆造纸中段废水的研究

化工与环境工程 | 更新时间：2026-09-14

- 聚铁与聚铝联用处理草浆造纸中段废水的研究
- Study on the Treatment of Wastewater from Straw Pulping Process by Using both PFS and PAC
- 中北大学学报（自然科学版） 2011年32卷第4期页码：490-495
- 作者机构：
  
  1. 上海大学环境与化学工程学院
  2. 浙江清华长三角研究院生态环境研究所
  3. 上海上大玲珀化工科技有限公司
- 作者简介：
- 基金信息：
  
  上海市重点学科第3期建设项目(S30109);浙江省省长基金资助项目(2007C18002)
- DOI：
  中图分类号：
- 纸质出版：2011
- 稿件说明：
移动端阅览
杨宇, 刘锐, 朱勇强, 等. 聚铁与聚铝联用处理草浆造纸中段废水的研究[J]. 中北大学学报（自然科学版）, 2011,32(4):490-495.

杨宇, 刘锐, 朱勇强, et al. Study on the Treatment of Wastewater from Straw Pulping Process by Using both PFS and PAC[J]. 2011, 32(4): 490-495.
杨宇, 刘锐, 朱勇强, 等. 聚铁与聚铝联用处理草浆造纸中段废水的研究[J]. 中北大学学报（自然科学版）, 2011,32(4):490-495. DOI：

杨宇, 刘锐, 朱勇强, et al. Study on the Treatment of Wastewater from Straw Pulping Process by Using both PFS and PAC[J]. 2011, 32(4): 490-495. DOI：

摘要

针对草浆造纸中段废水的特性

提出了联合使用混凝剂聚合硫酸铁(聚铁)和聚合氯化铝(聚铝)的处理工艺.结果表明:与单独使用聚铁或聚铝相比

聚铁和聚铝联用可提高对COD、浊度和色度的净化效果.投加助凝剂聚丙烯酰胺明显加大了絮体沉降速度

在一定的程度上减少了絮体发生量.聚铁、聚铝和聚丙烯酰胺联用工艺在最佳的工艺条件下对浊度、色度和COD分别为107 NTU和3570倍和1550 mg·L-1的原水的处理率分别达到了97.3%

96.6%和82.1%.

Abstract

Based on characteristic of wastewater from straw pulping process

the process of treating the wastewater by using both polyferric sulphate(PFS) and polyaluminum chloride(PAC) as coagulant was sugested.The results show that the removal rates of COD

turbidity and color are increased by using both PFS and PAC

compared with by using single PFS or PAC.It is clear that using polyacrylamide(PAM)as flocculant when using PFS and PAC can speed up settling rate and reduce the volume of floc to a certain.The wastewater with 107 NTU of turbidity

3 570 dilution ration of color and 1 550 mg·L-1 of COD was treated by using PFS

PAC and PAM under the optimal process condition

and the removal rates of turbidity

color and COD reached 97.3%

96.6% and 82.1% respectively.

关键词

Keywords

references

杨卿,张安龙.SBR处理草浆中段废水的研究[J].纸和造纸,2005,3(2):75-77.Yang Qing,Zhang Anlong.Study on treatment of straw pulping middle stage waste water with SBR[J].Paper andPaper Making,2005,3(2):75-77.(in Chinese)

杨学富.制浆造纸工业废水处理[M].北京:化学工业出版社,2001.

常青.水处理絮凝学[M].北京:化学工业出版社,2002.

李明玉,袁金芳,唐启红,等.聚合硫酸铁的制备及在造纸废水处理中的应用[J].化学研究,2000,11(1):29-31.Li Mingyu,Yuan Jinfang,Tang Qihong,et al.Preparation of polymeric ferric sulfate and application in waste watertreatment in paper-making[J].Chemical Research,2000,11(1):29-31.(in Chinese)

梁拴粉,张安龙.PAC和PAM对碱法草浆中段废水脱色效果的研究[J].西南造纸,2006,35(5):39-40.Liang Shuanfen,Zhang Anlong.Study on decolorizing effect of PAC and PAM in alkali straw pulp bleaching effluent[J].Southwest Pulp and Paper,2006,35(5):39-40.(in Chinese)

李德有,张如意.聚合氯化铝处理造纸中段水效果的研究[J].工业水处理,2001,21(1):42-43.Li Deyou,Zhang Ruyi.Study of the effect of polyaluminium chloride on treating the grey water of paper industry[J].Industrial Water Treatment,2001,21(1):42-43.(in Chinese)

刘存海,王廷平.造纸黑液处理技术的研究[J].黑龙江造纸,2006(4):13-15.Liu Cunhai,Wang Tingping.The black liquor of papermaking of flocculation and oxidation[J].Heilongjiang Pulp&Paper,2006(4):13-15.(in Chinese)

黄胜.聚铝和聚铁在造纸废水处理中的交互作用[J].华中科技大学学报(自然科学版),2004,32(3):51-53.Huang Sheng.Study of coagulant interaction in treatment of pulping waste water by using PAC and PFS together[J].J.Huazhong University of Science&Technology(Nature Science Edition),2004,32(3):51-53.(in Chinese)

Srivastava V C,Mall I D,Mishra I M.Treatments of pulp and paper mill wastewaters with poly aluminium chlorideand bagasse fly ash[J].Colloids Surf.A,2005,260:17-28.

Katja H,Mika S.Flocculation in paper and pulp mill sludge process[J].Research Journal of Chemistry andEnvironment,2007,11(3):96-103.

甘莉,甘光奉.铝铁复合剂的研究新进展[J].工业用水与废水,2003(1):63-65.Gan Li,Gan Guangfeng.New progresses in development of ferroaluminium composite coagulants[J].IndustrialWater and Wastewater,2003(1):63-65.(in Chinese)

Gao B,Liu B,Chen T,et al.Effect of aging period on the characteristics and coagulation behavior of polyferricchloride and polyferric chloride-polyamine composite coagulant for synthetic dying wastewater treatment[J].Journal of Hazardous Materials,2011,187:413-420.

胡万里.混凝.混凝剂.混凝设备[M].北京:化学工业出版社,2001.

Wong S S,Teng T T,Ahmada A L,et al.Treatment of pulp and paper mill wastewater by polyacrylamide(PAM)in polymer induced flocculation[J].Journal of Hazardous Materials,2006,B135:378-388.

Ahmad A L,Wong S S,Teng T T,et al.Improvement of alum and PACl coagulation by polyacrylamides(PAMs)for the treatment of pulp and paper mill wastewater[J].Chemical Engineering Journal,2007,137(3):510-517.

浏览量

176

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

无甲醛水性内墙涂料的研制

沉淀聚合法合成聚丙烯酰胺

动爆试验中的自适应冲击波超压测试传感研究

基于低分子质量PEI的类PEG聚合物基因载体

面向高空爆炸试验的冲击波测试系统